To my surprise, there is a open safety recall for the EGR Cooler, this is a new one as it shows up on the dealer system but not the online BMW recall database. My car passed inspection on the first EGR Cooler recall (18V-755), but it seems like the car is now getting a redesigned part. 13 posts · Joined 2017. #1 · Jan 7, 2020. My 2010 318D showed reduced power engine fault sign which was traced to be due to faulty EGR valve.This was replaced by the mechanic but there is a engine sign coming on moment I start the car-possibly indicating a sensor or cable fault,and it stays on. Engine performs and sounds better since changing There is no need to fit EGR caps or EGR blanking plugs or EGR plates as it will be a waste of time and money. As you will still need to program the codes out in the Ecus software anyway after these EGR blank plugs have been fitted. So I would advise to program the EGR valve to stay closed correctly in the ECUs software at the time of the remap. A P0401 trouble code indicates that a problem has been detected in the Exhaust Gas Recirculation (EGR) system, typically due to a bad EGR valve. The EGR valve is an important part of a car’s emission control system, as it helps reduce the amount of nitrous oxide (NOx) emissions released into the atmosphere.

AFAIK, the recall iw for EGR Cooler, not EGR valve. EGR failure is quite common on the 6 cylinder diesels especially if you have been using cheap supermarket diesel. £1200 is way OTT for a simple EGR valve replacement and sounds more like the cost to replace the cooler. I would expect an EGR to be half that.

3 Adaptation of EGR valve An adaptation value is saved in the DDE control module for the EGR valve with move-away report. This adaptation value describes the position of the end stop of the exhaust gas recirculation valve. The service function (adaptation exhaust gas recirculation valve) must be run if the EGR valve was replaced.
Save. Doug Huffman Premium Member · #4 · Nov 26, 2021. X5 bittersweet said: Now engine light on again and diagnosis is a $3,242 repair at BMW. EGR valve is NOT $3,242 and that does not sound like a diagnosis. Diagnosis should cost a couple of FRU, one for hooking up the computer and maybe another for Test Plan. See all problems of the 2012 BMW X5 Gas Recirculation Valve (egr Valve) problems: 37. Engine Cooling System problems: 34. Engine Belts And Pulleys problems: 25.
DPFE Sensor Replacement Cost. The cost to replace a DPFE sensor and EGR valve range from $150 to $500. The parts tend to make up the majority of the cost, usually between $100 and $400, while the labor might only be $50 to $100. However, replacing the DPFE sensor is a simple task that can be done with a few everyday tools.
J48K.
  • 96xu4yw9jc.pages.dev/368
  • 96xu4yw9jc.pages.dev/269
  • 96xu4yw9jc.pages.dev/106
  • 96xu4yw9jc.pages.dev/256
  • 96xu4yw9jc.pages.dev/491
  • 96xu4yw9jc.pages.dev/35
  • 96xu4yw9jc.pages.dev/272
  • 96xu4yw9jc.pages.dev/163

    • bmw x5 egr valve problems